What is Volvo ETM?

What is Volvo ETM?

Volvos affected by the electronic throttle module (“ETM”) are 1999-2002 models (US model years). Before 1999, Volvo used a good old mechanical set of parts to control the throttle. In 1999, they switched to a “fly-by-wire” module… this problematic ETM. This design affects almost a half-million Volvo gasoline cars.

How do you reset the throttle body on a Volvo?

Fully depress the accelerator pedal for 10 seconds. At this point the check engine light should change to blinking slowly indicating “Erasing ECU Memory”. 8. Release the accelerator pedal and turn the ignition switch to off.

How do I reset my throttle body?

Resetting your electronic throttle control manually can be a tricky job. First, make sure the accelerator pedal is fully released. Next, turn the ignition on and then turn it off and wait for ten seconds. During these ten seconds, be sure the throttle valve is moving by listening for a sound of operation.

What is ETM testing?

IBM® Engineering Test Management™ is a collaborative, web-based, quality management solution that offers comprehensive test planning and test asset management from requirements to defects. Built on the Jazz platform, it enables teams to seamlessly share information.

What does a throttle body sensor do?

The throttle position sensor is mounted onto the throttle body and measures the opening and closing movements of the throttle valve and these are transmitted to an engine control module, this information, as well as other measurements including; temperature, engine RPM and mass air flow (MAF), are used by the engine …

What is Volvo CEM?

Central Electronic Module (CEM) is the main electrical module on Volvo vehicles that communicate with the rest of your car’s modules and components. When it fails, it can cause unpredictable intermittent electrical problems.

Are Volvos known for electrical problems?

2001 through 2013 Volvo vehicles are prone to intermittent electrical problems due to water getting to the Central Electronic Module. Corrosion on the CEM terminals can develop if you: live in a humid climate, if your vehicle has been in flood.

How to fix Volvo ETM?

A cost-effective way to fix Volvo ETM is to have a specialist repair your existing unit. You will need to remove it and send it in for repair. As ETM failures are widespread, several specialists offer Volvo ETM repair service on eBay. See the instructions below on how to remove Volvo ETM.

How much does it cost to repair a Volvo electronic throttle module?

Because the Volvo Electronic Throttle Module (ETM) is known to have a higher-than-normal failure rate, Volvo has extended the warranty of selected ETMs to 10 years/200,000 miles. The repair cost to fix this problem should be between $100 and $150 for labor. There were eight model years affected by this issue, from 2001 to 2008.

Are there any problems with the V70 S60 S80?

Volvo cars equipped with five-cylinder gasoline engines (V70 S60 S80) can suffer from rough idle and stalling problems. This article will discuss Volvo Electronic Throttle Module problems. Although not exclusively limited to, the most likely cause of this problem might be a failing Volvo Electronic Throttle Module (ETM).

What causes the throttle position sensor on a Volvo XC60 to fail?

Although not exclusively limited to, the most likely cause of this problem might be a failing Volvo Electronic Throttle Module (ETM). These cars use a fly-by-wire throttle. The failure is caused by wear in the internal throttle position sensor con sensor contacts.